Safari wont turn over after manual conversion

[tga_4x4]

Just put a manual box in the safari, wired up the loom from the manual and now truck wont turn over off key, I hooked up the auto shifter inhibator switch and still no luck, any ideas ?

[DieselBoy]

I wish I had a pic but I don't so here goes.......

Beside the drivers side battery is bank of rectangular plugs.

The black plug (pretty sure its the top plug) as four or six (?) wires into it. You would have unplugged the Auto loom from this one.

On the plug, there are two wires that are heavier gauge than the others. You need to loop those two together to make the circut. Just use a 50mm section of wire and two spade terminals. That will tell everything that the trucks in park or neutral and turn the start inhibitor off.

I can get Toyoda to take a Pic of what I did to his if required

[tga_4x4]

I wish I had a pic but I don't so here goes.......

Beside the drivers side battery is bank of rectangular plugs.

The black plug (pretty sure its the top plug) as four or six (?) wires into it. You would have unplugged the Auto loom from this one.

On the plug, there are two wires that are heavier gauge than the others. You need to loop those two together to make the circut. Just use a 50mm section of wire and two spade terminals. That will tell everything that the trucks in park or neutral and turn the start inhibitor off.

I can get Toyoda to take a Pic of what I did to his if required

Cant see the block that has 4 or 6 wires that has 2 heavier wires on it

[ToYoda]

Think this is it...

http://i1105.photobucket.com/albums/h35 ... MG2228.jpg

http://i1105.photobucket.com/albums/h35 ... MG2227.jpg

http://i1105.photobucket.com/albums/h35 ... 2229.jpgmg

[DieselBoy]

That's the one

[tga_4x4]

That's the one

Yep got it...bloody thing was hiding....

[Shane]

Responce time 19 mins (db)

I need to lift my game

24hrs to late

Shane

[tga_4x4]

Responce time 19 mins (db)

I need to lift my game

24hrs to late

Shane

All good mate, pretty happy with the conversion although loosing 400 rpm from the auto to manual in top gear at 100kph is going to take a little getting used to, oh well better put some 35's on to compensate

[ToYoda]

Always surprises me the lack of difference in gearing between 4 and 5th!

[Shane]

Always surprises me the lack of difference in gearing between 4 and 5th!

I know,and theres such a big jump from 2nd to 3rd,manual is great with 35's though,engine braking much better also.