something is up here

[ArvinSlayer]

so after i recently cleaned my manifold and blocked off my EGR, my fuel economy has just gone to shit...i barely get 500kms to the full tank... Help?

Its stock standard except for the poddy and the bigger exhaust...m getting an intercooler tmrw, reckon installing that will help fuel economy?

cheers

Arvin

[ArvinSlayer]

Its a 1990 Terrano 2.7T auto

[DieselBoy]

Get rid of the pod.

[ArvinSlayer]

and plumb in a snorkel?? how much would tht cost, as i dunt have much cash in hand...make another CAI? Just for clarification, why would removing the pod help?

cheers

Arvin

[DieselBoy]

I'm just guessing, but I imagine you have put a pod straight on the end of the turbo like I have seen others do on their TD27s.

It just ends up drawing hot air from the engine bay.

We all know that a couple of degrees in air temp makes a big difference in performance on a turbo diesl.

Either make a proper cold air box to go with it, or fit the standard air cleaner back on.

A snorkle will increase your fuel consumption as it is a further restriction to the intake system.

[ArvinSlayer]

This is my current set up, i made pipe, was thinking bout making a box around it awile ago u can see it in here

http://www.offroadexpress.co.nz/Forums/ ... 18&t=28135

bt yea, it was fine when i initially had the pod, it was fine, all until I cleaned the manifold n blocked the EGR

[coxsy]

maybe no sealing well as a guess

[tallsam66]

My guess is when you put the manifold back on you didnt do it properly & now its sucking air in ....after all it was the last thing you did.

[ArvinSlayer]

hmmm u might have a point, i need to get me the metal manifold gaskets again, cause the one i got from repco was paper, n its shit. how do i check if i am sucking/losing air around the manifold seals?

Cheers

Arvin

[DieselBoy]

Spray liberal amounts of crc or brake clean around the manifold joints at hot idle and listen to see if there is a TINY increase in revs.

[tweake]

does the terrano have an egr butterfly in the intake?

[sibainmud]

Hey, I'm not being critical here, but where is all the fuel going?
It will be black smoking (unburned fuel) or falling out on the ground (leaking fuel pump).
No disrespect DB, but as you know I ran a pod on the turbo for a few years and even with a leaking fuel pump, I could still get over 600k's from a tank.
With a manifold air leak, wouldn't make that much difference with a diesel as they don't have vacuum in the manifold at any stage through the rev range so it would be boost it would be losing.
Situations like this, it may be worth upping the boost a bit so you produce more horsepower and end up not needing so much throttle to get the same pick up.
I will be watching with interest.

Cheers,

[sibainmud]

does the terrano have an egr butterfly in the intake?

Yip. One would hope it has been removed or jambed open. I was going to cover that up there ^^^ but lets just go one step at a time

Cheers,

[The Stranger]

Hey, I'm not being critical here, but where is all the fuel going?
It will be black smoking (unburned fuel) or falling out on the ground (leaking fuel pump).
No disrespect DB, but as you know I ran a pod on the turbo for a few years and even with a leaking fuel pump, I could still get over 600k's from a tank.
With a manifold air leak, wouldn't make that much difference with a diesel as they don't have vacuum in the manifold at any stage through the rev range so it would be boost it would be losing.
Situations like this, it may be worth upping the boost a bit so you produce more horsepower and end up not needing so much throttle to get the same pick up.
I will be watching with interest.

Cheers,

When I upped the boost on mine it blew a joint in the inlet tract apart a little.
There was no discernable additional smoke, and the milage decreased.
Having seen that it sounds plausable to me.

[slide]

so after i recently cleaned my manifold and blocked off my EGR, my fuel economy has just gone to shit..

How about engine power?? Has power reduced at same time? Or still about same? Or increased?

[ArvinSlayer]

so at the moment the most boost it will be pushing might b about 13psi, (off at the intake manifold), as i have blocked the regulator hose that goes into the wastegate actuator.

so to pile the boost on, i gotta weld up the valve on the manifold, intercool and then dial it up with a boost controller right?

Cheers

Arvin

[ArvinSlayer]

so after i recently cleaned my manifold and blocked off my EGR, my fuel economy has just gone to shit..

How about engine power?? Has power reduced at same time? Or still about same? Or increased?

I havent had a massive increase in power, but i have more power in the lower to mid range, top end power pretty much the same, as a benchmark, i went up the bombays northbound before and after i cleaned the manifold, it held 110kms upwards, but it was a tad cooler after the manifold was cleaned, mind you i had to let the hot air thru by having the heater on full blast.

cheers

Arvin

[pressy]

here have a look and /or ask this guy http://www.trademe.co.nz/Members/Listin ... er=3911464
my mate got one and its is a copy of a safari snorkel minus the badging. just got another for a 80 crusier and looks like a air flow snorkel copy. and cheap too.

[tweake]

does the terrano have an egr butterfly in the intake?

Yip. One would hope it has been removed or jambed open. I was going to cover that up there ^^^ but lets just go one step at a time

Cheers,

blocking egr and leaving egr butterfly operating can increase fuel consumption, especially on worn engines.

[sibainmud]

i went up the bombays northbound before and after i cleaned the manifold, it held 110kms upwards, but it was a tad cooler after the manifold was cleaned

I did the same test on Sunday arvo. 5th gear, started at 102k's (i phone GPS), put my foot flat to the floor. EGT's 550deg max, engine temp went up slightly (just over half), constant 19 psi boost, passed everything and was still doing 102k's at the top. Successful test me thinks.

13 psi is all you can get without removing or disabling the relief valve. If you are rough, smack the top of the mushroom with a big hammer or remove the valve and replace it with a steel blanking plug. With the waste gate hose disconnected and blocked of you should get between 16psi-18psi boost easy. I have done this to 2 terranos now and both have produced a heap of power.

Cheers,

[ArvinSlayer]

alrite the fuel problem seemed to have fixed itself after i installed a new fuel filter and bled the fuel lines!