Am at a loss as to why every time I start driving my diff shudders.
Its only at take off once im moving its fine.
Any Ideas ?
Terrano diff shudder
Moderator: Mark
Re: Terrano diff shudder
How do you know it's your diff that is shuddering?
Is your vehicle auto or manual? If manual, the clutch can get a bit of crap between it and the flywheel causing shuddering under take off.
Is your vehicle auto or manual? If manual, the clutch can get a bit of crap between it and the flywheel causing shuddering under take off.
Toyhatsu Bitsalux
Re: Terrano diff shudder
Rear driveshaft UJ? You could re-pack it with grease, see if it helps. Or grab another low mileage driveshaft for $20 or so from a wrecker.
How many miles on the truck?
How many miles on the truck?
Re: Terrano diff shudder
Does the rear driveshaft have a centre hanger bearing?
My LN106 had the same issue, the rubber in the hanger bearing was flogged out, replacing it fixed the problem.
My LN106 had the same issue, the rubber in the hanger bearing was flogged out, replacing it fixed the problem.
Re: Terrano diff shudder
I will try the repacking the UJ with grease and see if that helps.
Its a 1 piece driveshaft and the clutch is less than 15000km since it was replaced.
Im not 100% sure of milage as I have a feeling the previous owner may have rewound it but it says 305,000km I would say more along the lines of 400km.
Its a 1 piece driveshaft and the clutch is less than 15000km since it was replaced.
Im not 100% sure of milage as I have a feeling the previous owner may have rewound it but it says 305,000km I would say more along the lines of 400km.
-
ChurchurDan
- Hard Yaka
- Posts: 574
- Joined: Sun May 12, 2013 7:49 pm
- Location: North Canterbury
Re: Terrano diff shudder
The new clutch I fitted to mine about 4 years ago started shuddering in about 10000ks, it still does it but I cant be arsed taking it back out. I find if I give it a bit of a burn( 4th gear handbrake on lots of revs and let clutch out till it slips and tries to drive for a few seconds) it will stop shuddering for a little while.
I assume it is either because I didn't get the flywheel surfaced or the clutch disc has broken springs or shit friction material.
I assume it is either because I didn't get the flywheel surfaced or the clutch disc has broken springs or shit friction material.
Re: Terrano diff shudder
ChurchurDan wrote:The new clutch I fitted to mine about 4 years ago started shuddering in about 10000ks, it still does it but I cant be arsed taking it back out. I find if I give it a bit of a burn( 4th gear handbrake on lots of revs and let clutch out till it slips and tries to drive for a few seconds) it will stop shuddering for a little while.
I assume it is either because I didn't get the flywheel surfaced or the clutch disc has broken springs or shit friction material.
If I dont have any luck with the UJs I may just pull the box out and check the clutch.
Good excuse to do some mods while im at it
