Page 1 of 1
Safari wont turn over after manual conversion
Posted: Thu Nov 10, 2011 9:30 am
by tga_4x4
Just put a manual box in the safari, wired up the loom from the manual and now truck wont turn over off key, I hooked up the auto shifter inhibator switch and still no luck, any ideas ?
Re: Safari wont turn over after manual conversion
Posted: Thu Nov 10, 2011 9:49 am
by DieselBoy
I wish I had a pic but I don't so here goes.......
Beside the drivers side battery is bank of rectangular plugs.
The black plug (pretty sure its the top plug) as four or six (?) wires into it. You would have unplugged the Auto loom from this one.
On the plug, there are two wires that are heavier gauge than the others. You need to loop those two together to make the circut. Just use a 50mm section of wire and two spade terminals. That will tell everything that the trucks in park or neutral and turn the start inhibitor off.
I can get Toyoda to take a Pic of what I did to his if required
Re: Safari wont turn over after manual conversion
Posted: Thu Nov 10, 2011 11:25 am
by tga_4x4
DieselBoy wrote:I wish I had a pic but I don't so here goes.......
Beside the drivers side battery is bank of rectangular plugs.
The black plug (pretty sure its the top plug) as four or six (?) wires into it. You would have unplugged the Auto loom from this one.
On the plug, there are two wires that are heavier gauge than the others. You need to loop those two together to make the circut. Just use a 50mm section of wire and two spade terminals. That will tell everything that the trucks in park or neutral and turn the start inhibitor off.
I can get Toyoda to take a Pic of what I did to his if required
Cant see the block that has 4 or 6 wires that has 2 heavier wires on it
Re: Safari wont turn over after manual conversion
Posted: Thu Nov 10, 2011 2:08 pm
by ToYoda
Re: Safari wont turn over after manual conversion
Posted: Thu Nov 10, 2011 2:53 pm
by DieselBoy
That's the one
Re: Safari wont turn over after manual conversion
Posted: Thu Nov 10, 2011 4:20 pm
by tga_4x4
DieselBoy wrote:That's the one
Yep got it...bloody thing was hiding....
Re: Safari wont turn over after manual conversion
Posted: Fri Nov 11, 2011 7:58 am
by Shane
Responce time 19 mins (db)
I need to lift my game
24hrs to late
Shane
Re: Safari wont turn over after manual conversion
Posted: Fri Nov 11, 2011 8:44 am
by tga_4x4
Shane wrote:Responce time 19 mins (db)
I need to lift my game
24hrs to late
Shane
All good mate, pretty happy with the conversion although loosing 400 rpm from the auto to manual in top gear at 100kph is going to take a little getting used to, oh well better put some 35's on to compensate
Re: Safari wont turn over after manual conversion
Posted: Fri Nov 11, 2011 12:18 pm
by ToYoda
Always surprises me the lack of difference in gearing between 4 and 5th!
Re: Safari wont turn over after manual conversion
Posted: Fri Nov 11, 2011 8:09 pm
by Shane
ToYoda wrote:Always surprises me the lack of difference in gearing between 4 and 5th!
I know,and theres such a big jump from 2nd to 3rd,manual is great with 35's though,engine braking much better also.
