Page 1 of 1
Rear Diff Info Needed - HG46
Posted: Mon Feb 18, 2013 1:24 pm
by fullthrottle
Hi All
Been looking through all my Nissan manuals, but can't find anything on the rear Diff installed in my Terrano
Its a LSD....
HG46
....apparently a bus/truck diff.
Is one of the other models similar in setup?
R180A
R200A
H190A
C200
H233B
I'm just researching schiming the LSD plates to tighten it up a bit more.
Cheers
Re: Rear Diff Info Needed - RE4R01A HG4b
Posted: Mon Feb 18, 2013 3:13 pm
by Dirtydog
ya sure its not a hg46?
thats what mine is, h233b with 4.6 ratio.
Re: Rear Diff Info Needed - RE4R01A HG4b
Posted: Mon Feb 18, 2013 3:17 pm
by meatc
The RE****** number you refer to is the gearbox not the diff. The HG** id the diff. As above it will be HG46 not 4b,
Re: Rear Diff Info Needed - RE4R01A HG4b
Posted: Mon Feb 18, 2013 4:20 pm
by fullthrottle
Ahhh yeah, 46 not 4b. Hard to read that plate in the engine bay.
So its just a h233b with a 4.6 ratio, correct?
Re: Rear Diff Info Needed - RE4R01A HG4b
Posted: Mon Feb 18, 2013 4:25 pm
by Dirtydog
thats correct. if its got a c200 type diff, it would read CA**
Re: Rear Diff Info Needed - HG46
Posted: Mon Feb 18, 2013 4:38 pm
by fullthrottle
Cheers guys. Good info
Re: Rear Diff Info Needed - HG46
Posted: Mon Feb 18, 2013 5:22 pm
by Crash bandicoot
fullthrottle wrote:Hi All
Been looking through all my Nissan manuals, but can't find anything on the rear Diff installed in my Terrano
Its a LSD....
HG46
....apparently a bus/truck diff.
Is one of the other models similar in setup?
R180A
R200A
H190A
C200
H233B
I'm just researching schiming the LSD plates to tighten it up a bit more.
Cheers
HG46 is combination axle code. HG designates the rear axle as an H233B. 46 designates the gear ratios as 4.625:1
This one has some variation. Pre-2000 versions are the H233B axle with 4.625:1 gearing (31 spline axles). 2000+ is the H233B axle with 4.636:1 gearing (33 spline axles)
It is usually mated to an R200 front diff.
Re: Rear Diff Info Needed - HG46
Posted: Fri Feb 22, 2013 11:32 pm
by charo249
C200 and H233 diffs both run the same clutch plates in their LSD so won't matter if you do get it wrong. But the 46 refers to the ratio - and if it has a removable cover plate is is a C200, if it doesn't it will be an H233 (this diff is also bigger).
Re: Rear Diff Info Needed - HG46
Posted: Sat Feb 23, 2013 12:03 am
by lax2wlg
Yep and the numerical part indicates ring gear size in mm - C200 200mm (8"), H233 233mm (9.25")
fullthrottle if this is still the stern of your truck, its an H233. AFAIK the C200 was discontinued on the WD21 platform in 1990 when the first TD27 turbos came out, but continues to remain in use in the latest Navara/Frontier/Xterra.
IMO the H233 is kind of an overkill in a compact truck, the entire axle assembly weighs in close to half a ton.
Re: Rear Diff Info Needed - HG46
Posted: Sat Feb 23, 2013 11:45 am
by Dirtydog
Re: Rear Diff Info Needed - HG46
Posted: Sat Feb 23, 2013 12:41 pm
by fullthrottle
Don't think he's broken a rear diff yet
Re: Rear Diff Info Needed - HG46
Posted: Sun Feb 24, 2013 11:10 pm
by reef
hey can any one help me with what diff oil i should use for my 92 D21 27TD, for both front and rear diffs????
and how much should i put in???
Re: Rear Diff Info Needed - HG46
Posted: Mon Feb 25, 2013 12:21 am
by lax2wlg
Re: Rear Diff Info Needed - HG46
Posted: Mon Feb 25, 2013 9:47 am
by keithal
lax2wlg wrote: AFAIK the C200 was discontinued on the WD21 platform in 1990 when the first TD27 turbos came out,
my old 1991 2 door non turbo had a c200
Re: Rear Diff Info Needed - HG46
Posted: Mon Feb 25, 2013 4:16 pm
by sibainmud
fullthrottle wrote:Don't think he's broken a rear diff yet
Nup still running the first H233 I put a chinese air-locker in when I swapped from C200 in T1 that was non-turbo. Onto it's second truck now and still going strong. Only had to rebuild locker once to resize O rings and replace spider gear thrusts.
Over-kill comes to mind
Cheers,
Re: Rear Diff Info Needed - HG46
Posted: Mon Mar 04, 2013 10:11 pm
by kiwinoz
Pity they didnt go to the bigger gearbag when they put in the H233, think of all the time and money we all would've saved
Re: Rear Diff Info Needed - HG46
Posted: Sat Apr 13, 2013 12:32 am
by tatnz
Hay man have a look at the rebuild I did here is a link
http://www.offroadexpress.co.nz/Forums/viewtopic.php?f=25&t=29867I have a pdf manual for the terrano/parthfinder that has all the info you will ever need if you would like I could e mail it to you, I run 32'' wheels and its like a lock diff I had in my old v8 but its a start.
